Company News
-
The Cause and Treatment of diesel generator output power shortage?
Diesel generator output is lacking Fault cause: blockage of fuel filter constitutes poor oil supply; Fuel oil pipeline leakage, air into the intake pipe; The air filter of the initiator is blocked and the intake is not smooth. Fuel temperature is too high; The exhaust pressure of the initiator is...Read more -
The engine can not reach the rated speed of the cause and solution?
1. The engine load is too large relative to the rated power Solution: Reduce the load 2. The tachometer is faulty Solution: Check with a handheld tachometer 3. Throttle control lever is improperly adjusted Solution: Check the throttle stroke 4. The oil suction circuit is blocked Solution: Clean t...Read more -
What are the inspection methods for diesel engine failure?
What are the methods to check the fault of diesel generator? 1. Partition method. The partition method is to stop the single cylinder of the diesel engine or stop the injection of several or even all cylinders one by one, and observe the work changes before and after the diesel engine and stop th...Read more -
How to determine the replacement time of diesel generator oil and three filters?
How to determine the replacement of diesel generator set oil and machine filter, wood filter and air filter? Teach you three ways to get it done: 1, with two 0.5cm diameter, 20 cm long glass test tube, respectively loaded with 19 cm of new oil and used oil, sealed two tubes inverted at the same t...Read more -
Diesel generator common problem solution?
A series of problems will inevitably occur in the daily use of diesel generator set, so how to solve them effectively? 1, the generator (electric ball) loss of magnetism is what happened, how to deal with? A: The generator (electric ball) for a long time, resulting in the loss of residual magneti...Read more -
What is an automated diesel generator set?
The concept of automatic diesel generator set is relative to the basic type of generator set, automatic diesel generator set is automatically started, when the unit meets the parameters of the operation standard through the double power switch automatic switch, no manual operation, but must use t...Read more -
What are the problems that should be paid attention to during the use of diesel engine?
(1) Problems that should be paid attention to when starting Small diesel engine start properly save time and labor, reduce machine wear; Otherwise, it will delay time and affect the work. The following problems must be paid attention to when starting: (1) Pre-lubrication before starting. When the...Read more -
Diesel generator silencer project introduction?
When the running speed of a generator set is 1500rpm, 105 decibels of noise will be generated one meter away from the generator set. In order to avoid the noise from the machine room, the noise reduction project should include the following steps: First, the machine room out of the entrance noise...Read more -
How to repair the supercharger fault?
Why is supercharger diesel engine most prone to failure? Because the rated working speed of the supercharger is more than 130,000 revolutions per minute, and at the outlet of the exhaust manifold, the temperature is extremely high (above 800℃), the inlet and exhaust pressure is also large, that i...Read more -
What are the common wrong operations of diesel generator sets?
The wrong operation of diesel generator will seriously affect the service life of diesel generator set. Here we come to understand what are the wrong operation modes of diesel generator set in daily life? Diesel generator error operation one: emergency stop with load or sudden discharge of load i...Read more -
Why does diesel generator set appear “tour car” phenomenon?
The “running” fault of diesel engine refers to the regular speed up and down. This fault is generally due to the fuel supply system in the air or governor caused by disorders. Cause of failure: 1. The oil supply adjusting tooth rod in the fuel injection pump is stuck. 2. The backlash ...Read more -
Delivery site of fully automatic Shangchai 300kw silent diesel generator set
A fully automatic 300kw silent diesel generator set from Shangchai Co., Ltd. was produced in our factory this morning. It has been packed in trucks and is ready to be sent to South Africa. This Shangchai 300kw diesel generator set controller adopts the perfect combination of Zhongzhi and ats dual...Read more