News
-
The cause of oil leakage of diesel generator sets and the harm of oil leakage to diesel generator sets?
Oil leakage of diesel generator set is one of the common faults of diesel generator set, oil leakage not only wastes resources, but also affects the stability of generator operation. Once there is oil leakage, it must be dealt with to avoid unnecessary losses. What are the causes of oil leakage o...Read more -
Diesel generator set overspeed failure shutdown how to do?
1, check the tachometer indication is abnormal 2, for the mechanical speed control system, check whether the throttle rod is flexible and ensure correct adjustment 3, for the electronic speed control system, check whether the throttle rod is flexible, check whether the actuator is acting correctl...Read more -
Diesel engine oil pressure is too low how to do?
Diesel engine oil pressure is too low causes of problems: 1. Crankcase oil level is too low or no oil; 2. The initiator coolant temperature is always maintained at a high temperature value, resulting in low oil viscosity; 3. The oil pressure sensor is defective or the sensor signal may be short-c...Read more -
Diesel generator set antifreeze choice?
The wrong choice of antifreeze will bring no small harm to the generator set. How to choose the right antifreeze? Diesel generator antifreeze is divided into the following conditions according to the change in temperature: 1. In southern China, water is usually used as coolant when the temperatur...Read more -
How to remove the scale produced by the radiator of diesel generator set?
1. Drain the water from the cooling system, and then disassemble the pipe from where the diesel engine is connected. 2. Accurate 4% of the rust removal acid solution and water, the acid into the water, do not reverse. 3. Let it mix for a few minutes, then heat the solution to 49 ° C (120 ° F), th...Read more -
The battery of a diesel generator can be safely started if there is enough power
Batteries are important for diesel generators, which can only be started effectively when there is sufficient power, which is necessary to successfully start each generator. Therefore, the guarantee of battery power supply is very important. ITO Power believes that in battery charging, everyone s...Read more -
How to prevent bubbling of diesel generator tank?
How to prevent bubbling in the fuel tank of the diesel generator set is because the high-pressure gas in the cylinder intrudes into the cooling waterway. The causes and removal methods of gas channeling are as follows. 1. The head nut is not tightened according to the specified torque. If the tor...Read more -
Correct use and maintenance of oil pump?
1. Before installing the oil pump of the diesel generator, it is necessary to confirm whether the model and specification are correct, remove the anti-rust oil, properly select the thickness of the gasket, so that the piston is too thin or too thick, to prevent the piston from dying or working no...Read more -
Technical points to know about 5 diesel generators?
Technical points to understand for 5 diesel generators 1. The use of oil filter: oil, friction caused by particles, parts of dirty debris, high temperature produced by early oxidation metamorphic particles mixed together. These particles are mixed with nails, sand, colloids, etc., can reduce the ...Read more -
How to remove the scale produced by radiator of diesel generator set?
1. Drain the water from the cooling system and remove the pipe from where the diesel engine is connected. 2. Accurate 4% of rust removal acid solution and water, acid into the water, do not reverse. 3. Let it mix for a few minutes, then heat the solution to 49 ° C (120 ° F), the highest point, bu...Read more -
Brushless generator advantages?
Advantages of brushless generator: 1, brushless generator running sound is small This will be the direction in which our civilized society is bound to move. In addition, it is required to reduce noise to protect our sound environment. 2. Brushless generator has no spark You can use it in some pla...Read more -
Which diesel generator checks should be done by electricians?
As we all know, diesel generators must pass strict inspection before they are put into operation. Strictly speaking, some tests are not for everyone and need to be performed by professionals. For example, some inspections must be carried out by professional electricians. Which diesel generator ch...Read more