Check and notice before operation of Volvo diesel generator set

The Volvo diesel generator set can be put into operation after installation. In order to ensure the accuracy and accuracy of the Volvo diesel generator set and ensure the integrity of the equipment, necessary checks should be carried out before each start up. Volvo diesel generator set surface and surrounding debris.

The device and connection of the Volvo diesel generator set should be fastened, whether the operating mechanism is flexible and whether the turning wheel is blocked. Check whether the intake and exhaust channels in the equipment room are *. Check whether the cooling system is normal. If the tank is full, pour the coolant into the water inlet of the tank. Whether the air filter is working properly.

Whether the oil level of the lubricating oil is within the normal range, the injection amount of the lubricating oil should reach the MAX mark on the existing ruler and not lower than the MIN position. Otherwise, please open the cover of the lubricating oil filling hole and fill. The lubricating oil filling should meet the required grade.

Whether the fuel tank stock is sufficient to meet the requirements of the specified running time. If the amount of oil is insufficient, open the fuel injection port cover and fill the fuel. Whether to open the oil supply valve, loosen the exhaust bolt of the high-pressure oil pump, drain the air in the fuel line, and tighten the exhaust bolt.

Electrical lines (including charging and starting circuits) are properly connected and in good contact. Diesel engine supply, lubrication, cooling and other systems of the pipe joints are leaking oil.

The dry load battery level is normal, the power is sufficient, and the battery cable is correctly connected. The position of each switch on the control screen is normal, and ensure that the output circuit breaker is in the gate position (OFF state). It is strictly prohibited to start the Volvo diesel generator set with the Volvo diesel generator set. The control screen of the Volvo diesel generator set should be set in manual mode.